NP233 electric shift to manual shift swap

FROM AWD'S TO 2-SPEED MANUAL SHIFT, IF IT LINKS THE REAR AXLE TO THE FRONT AXLE, POST IT HERE.
Post Reply

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

I want/need a true transfer case with low range so I decided to go with a NP233. Initially I wanted to use all the electronics and wire it in all proper like. After messing with and trying to figure out the wiring as none of the diagrams I found were the same, I decided to convert to manual shift. The reason I went with a 233 instead of a 231 is that all the 231's I have seen pics of have a yoke on the front output and with the 233, the stock drive shafts will fit with no mods.

Image

Pulled the shift motor/encoder off...

Image

Image

Image

Image

Image
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

Just for future reference on installing a low range switch for the PCM.

ASV link
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

Started making the shifter pivot bushing assembly. I also ordered a cable and a couple rod end clevises for the cable. Going with cable shifted just like I did the SPB. It worked well and makes for only a single hole drilled through the floor.

Image

Image

This shoulder bolt will be bolted to the seat frame and have a shifter handle and cable linkage arm welded to it.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy
User avatar

potskie
ASV Supporter
ASV Supporter
Posts: 769
Joined: Sat Jun 09, 2007 9:13 am
Location: Waterloo, ON

Re: NP233 electric shift to manual shift swap

Post by potskie »

You can always use a 231 later....... they are better for doubling anyways :whistle:


Is this the start of the monster that I'm sure next year at some point I will see on the front of PBB and a vid on the powerblock?
Image 98 Safari RWD. Stock.
Do you smell what Barack is cookin ?!?!

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

No plans for a doubler or for a SAS or any type of wheeling. I am hoping to lift it next spring but we'll see. My money is better spent these days on paying down our debt.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

Got my cable and clevis rod ends today! 1 day shipping from McMaster-Carr! The cable is stock number 1338K21 and the clevises are stock number 1583K12.

Image
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

Got a couple things done today...

Image

Image

Image

Image

Image

Image

Image
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

photo_van
I sleep in my van
Posts: 592
Joined: Wed May 18, 2011 4:38 pm
Location: 7000' in the Mountains of California
Been thanked: 3 times

Re: NP233 electric shift to manual shift swap

Post by photo_van »

Looks good, and the bonus is you probably can sell the module for the cost of the TC!

Gotta say I was disappointed you didn't go with the 242, but if a 233 would have been a no driveline mod to my '98 it would have been hard to resist.
1998 AWD/4WD
4" lift, 31x10.50's, NP 242j/c hybrid, 4.10 gears, S10 front disconnect, rack & pinion steering, trans cooler, rock sliders, ARB fridge, house battery and 100w solar, swing out rear rack with foldout camp table, bed and passenger swivel chair
dirt bag camping rig
1981 Toyota 4x4 pu
1974 John Deere 710
User avatar

mdmead
ASV Supporter
ASV Supporter
Posts: 2153
Joined: Sun Sep 10, 2006 6:45 pm
Location: Selah, WA
Been thanked: 1 time
Contact:

Re: NP233 electric shift to manual shift swap

Post by mdmead »

Very cool!
Matt
Selah, WA
-96 GMC Safari AWD Hi-Top Conversion -->Stalled 5.3L swap & 5" lift
-74 Ford Bronco -->Far from perfect but mine!
-99 V-10 Ford Super Duty Super Cab 4x4 -->Stock with 285 Cooper ATs
-00 Ford Focus Wagon -->The Red Turd
-95 Ford 24' Class C Motorhome -->My big block sleeper
-07 Can-Am Outlander XT -->My yellow 4x4 quad for work & play
-04 Ski Doo REV Summit -->Still several chassis behind!


No new projects until the current ones are done!

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

The 242 would have been nice but I didn't want to spend the cash on the adapter and then modify the drive shafts. Hopefully I can build the rest of the cable mount and the shifter tomorrow.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

Got the mount and shifter done! Gonna paint them Christmas while I am at work and will install the next week when I am off.

Welded up the cable mount...

Image

Image

Added the cable...

Image

Image

Finished the shifter...

Image

Image

Yeah, yeah...I know the van is a mess! :D Been raining here for a few weeks so there is a lot of dirt and mud in the van. Next nice day it'll at least get vacuumed out.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

Astrophysics
I sleep in my van
Posts: 974
Joined: Sat Jan 12, 2008 9:23 pm
Been thanked: 9 times

Re: NP233 electric shift to manual shift swap

Post by Astrophysics »

That is a great design. I plan to copy your idea for my 2003 AWD Astro next summer.

Thanks for great photos.

Astrophysics

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

Go ahead and copy it! :supz: The hardest part (for me) is going to be pulling up the carpet so I can drill through the floor and mount the cable and then get the carpet back down and looking good.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy

photo_van
I sleep in my van
Posts: 592
Joined: Wed May 18, 2011 4:38 pm
Location: 7000' in the Mountains of California
Been thanked: 3 times

Re: NP233 electric shift to manual shift swap

Post by photo_van »

you may be able to save yourself a lot of trouble by just mounting through the carpet and use a cover plate. Slightly different application in the photo, but I screwed the mount under the floor.I really didn't want to pull up the carpet!
_MG_8078.jpg
1998 AWD/4WD
4" lift, 31x10.50's, NP 242j/c hybrid, 4.10 gears, S10 front disconnect, rack & pinion steering, trans cooler, rock sliders, ARB fridge, house battery and 100w solar, swing out rear rack with foldout camp table, bed and passenger swivel chair
dirt bag camping rig
1981 Toyota 4x4 pu
1974 John Deere 710

Topic author
LiftedAWDAstro
I have my van tatooed on my cheeks
Posts: 4379
Joined: Sat Sep 09, 2006 3:35 pm
Location: New Haven, NY

Re: NP233 electric shift to manual shift swap

Post by LiftedAWDAstro »

I did that with the SPB and it worked good. I may do the same this time as the trim moulding screws are pretty rusty from salt.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition

Mileage spreadsheet

Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy
Post Reply