Gas Hand dance?
Gas Hand dance?
I just bought a 99 safari and the gas hand seems to be vibrating, it gives out an accurate reading i assume because i had half tank when i bought the van and ran it down to a little over empty but the gas hand just wont be still. Anyone else have this happen or heard of it?
-
- I have my van tatooed on my cheeks
- Posts: 4379
- Joined: Sat Sep 09, 2006 3:35 pm
- Location: New Haven, NY
Re: Gas Hand dance?
My old 98 Astro did this but it was always accurate. Never messed with it.
Current rides:
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition
Mileage spreadsheet
Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy
2013 Toyota Tundra DC 4x4
2008 Dodge Nitro 4x4
2005 Nissan Sentra 1.8S Special Edition
Mileage spreadsheet
Vans owned:
1986 Safari 2.5L 4 speed manual - scrapped
1995 Astro 2WD conversion 4.11 posi, shift kit, DHC rock rails - sold to Skippy
1998 Astro 4x4 D44, D60, NP231, full hydraulic system with 9k# Milemarker winch and snow plow - sold to Lockdoc
2003 Astro AWD all stock - traded for a 3/4 ton truck
2005 AWD, 4.10's - sold to skippy
-
- I plan to be buried in my van
- Posts: 2224
- Joined: Sun Jan 06, 2008 6:57 pm
- Location: Elgin, IL
Re: Gas Hand dance?
A lot of them bounce around a bit, but are near actual fuel level. My mind doesn't recall anyone actually taking the time to find a remedy.
Aaron
2005 Astro (Gandalf) - AWD, 4.3L, 3.42, 130k+ miles
1997 Astro (Grumpy - $250 Rally Van) - AWD, 4.3L, 3.42, LSD, 2" lift, 31" tires, 335k+ orig engine, $30 eBay fuel pump
Prev Astros:99,97,00,94,87,86
2005 Astro (Gandalf) - AWD, 4.3L, 3.42, 130k+ miles
1997 Astro (Grumpy - $250 Rally Van) - AWD, 4.3L, 3.42, LSD, 2" lift, 31" tires, 335k+ orig engine, $30 eBay fuel pump
Prev Astros:99,97,00,94,87,86
-
- ASV Supporter
- Posts: 1750
- Joined: Sat Jun 16, 2007 2:31 pm
- Location: Toronto, Ontario
- Has thanked: 1 time
- Been thanked: 1 time
Re: Gas Hand dance?
my 98 does it sometimes and is accurate my 97 is clearly affected by my turn signals..... but still accurate. Every time my turn signals come on the needle will drop then come back up when it goes back off the terminal on the battery looks like hell though cleaning the grounds i'm sure will fix my problem
1998 GMC Safari AWD, BFGoodrich AllTerrain T/A
Jet performance tuner 91 octane preset, Jet under-drive pulleys
Rancho 999000 series shock, on-board controller to be installed later
DHC rock rails and skid plate Add-A-Leaf
G3500 front calipers
Zexel Torsen Diff
11" drums
180 amp Alternator
Long tru-cool 4590 trans cooler
1997 gone
Jet performance tuner 91 octane preset, Jet under-drive pulleys
Rancho 999000 series shock, on-board controller to be installed later
DHC rock rails and skid plate Add-A-Leaf
G3500 front calipers
Zexel Torsen Diff
11" drums
180 amp Alternator
Long tru-cool 4590 trans cooler
1997 gone
-
- I plan to be buried in my van
- Posts: 1230
- Joined: Sun Sep 10, 2006 4:50 am
- Location: Billings, MT, 'MERICA!
Re: Gas Hand dance?
Mine does, too, but it turns out that is a small problem that can be ignored.
Mike, Billings, MT, 'MERICA!
92 Safari SLE w/Z Motor (sold to a good home)
98 AWD Stro LS
93 Suburban Silverado 4x4
Look for the MISSING Alien in the Right Seat. AL, PHONE HOME!!!
92 Safari SLE w/Z Motor (sold to a good home)
98 AWD Stro LS
93 Suburban Silverado 4x4
Look for the MISSING Alien in the Right Seat. AL, PHONE HOME!!!
Re: Gas Hand dance?
This happens because the dampening fluid in the gauge dries out over time. The PCM drives it with a PWM signal, and the fluid was to hold it still. I fixed my gauge by injecting some 50,000 wt silicone fluid. You have to take it all apart to do it though.
Scott
Scott